News
-
Important points to note during the transportation of diesel generator sets
During the transportation of diesel generator sets, there are some important precautions that everyone should be aware of. Below, the diesel generator set experts will introduce them to you in detail. Before handling the diesel generator. First, check and remove the relevant cables connecting th...Read more -
Key Points for Safe Use of Diesel Generators
The diesel generator sets must be operated by personnel who are familiar with the structure of the sets and have mastered the safety operation procedures. New or recently overhauled diesel generator sets should undergo 60 hours of warm-up operation as per regulations and receive necessary mainten...Read more -
Maintenance and servicing of diesel generators
A diesel generator is an independent power generation device, mainly providing emergency power during power outages. In fact, the generator is mostly in a standby mode and is rarely actually used. It is mainly tested and run in a trial state. There are relatively few complete detection and mainte...Read more -
Pre-start inspection of the diesel generator
1. All work tickets related to the diesel generator set have been completed. The diesel engine is idle without any operation or obstacles. 2. Check that the lubricating oil level of the diesel generator is normal. 3. Check that the water level of the cooling water of the diesel generator ...Read more -
The start and stop of the diesel generator
1. The startup methods of the diesel generator are divided into: automatic, remote (CRT screen soft operation) and local control panel manual startup. 2. The shutdown methods of the diesel generator are divided into: remote (CRT screen soft operation), local control panel shutdown or emer...Read more -
The diesel generator is operating normally
1. The diesel generator can operate continuously under the rated conditions. During operation, the following operating parameters should be monitored and checked to ensure they do not exceed (or fall below) the specified values: Voltage, current, frequency, power factor, lubricating oil p...Read more -
Inspection Items and Routine Periodic Tests of Diesel Generators
(1) Periodic Inspection Items for Diesel Generator under Automatic Mode Inspect the diesel generator set for any leakage. Check that the lube oil level is normal. Check the cooling water level. Check the oil levels of the storage fuel tank and daily service fuel tank. Verify that the local mode s...Read more -
Faults Occurring During Operation of Diesel Generator Sets and Their Troubleshooting
(1) The following faults occur during the operation of the diesel generator: The start-stop switch trips, the unit shuts down and the instrument panel triggers an alarm. If no tripping occurs, press the Emergency Stop button immediately for an emergency shutdown. Fault Causes: Overspeed High coo...Read more -
Causes and Troubleshooting Methods for Stuck Fuel Injectors of Diesel Generators
The fuel injector nozzle is one of the three pairs of precision matching parts in the fuel supply system of diesel engines. Its normal service life exceeds 1,000 operating hours. However, improper operation often leads to wear and seizure after only several hundred hours, or even dozens of hours ...Read more -
Operation and Maintenance of Diesel Generator Sets
Operation, Maintenance and Repair of Diesel Generator Sets Class A Maintenance (Daily Maintenance) Check the daily operation log of the generator set. Check the oil level and coolant level of the generator set. Daily inspection for damage and fluid leakage; check whether belts are loose or worn....Read more -
Principle of Diesel Generator
The diesel engine drives the generator to operate, converting the chemical energy of diesel fuel into electrical energy. Inside the cylinders of the diesel engine, clean air filtered by the air filter fully mixes with high-pressure atomized diesel injected through fuel injectors. As the piston m...Read more -
Matters Needing Attention for the Operation of Diesel Generators
The installation site shall be well ventilated. Sufficient air intake openings shall be provided at the generator end, and proper air outlets shall be arranged at the diesel engine end. The cross-sectional area of the air outlet shall be at least 1.5 times that of the water tank. The surro...Read more